How Tesla and Other EV Battery Fires Challenge First-Responder Tactics

© Provided by Consumer Reports

By Jeff Plungis, Consumer Reports

A new National Transportation Safety Board report on the fatal Florida crash of a Tesla Model S highlights the unique fire safety challenges posed by the batteries that power electric cars.

In the May 8 Fort Lauderdale crash, first responders used 200-300 gallons of water and foam to extinguish the flames, according to the NTSB preliminary report on the accident. After the fire was out and the vehicle was loaded onto a tow truck, the car caught fire again. After that fire was extinguished and the car was in the storage yard, it ignited a third time. A different fire department responded and put that blaze out.

According to Andrew Klock, emerging technologies program manager at the National Fire Protection Association in Quincy, Mass., electric vehicles (EVs) aren’t inherently more prone to fires than conventional gasoline cars. But when their batteries do ignite, the fires can behave very differently than a gasoline blaze. That makes these type of fires unpredictable and potentially dangerous for firefighters who may not have been trained to deal with battery fires.

A lot more water is required for EV fires than conventional fires, Klock said. That’s because it’s critical for firefighters to lower the temperature of the burning lithium-ion cell. Conventional car fires can be smothered with water and foam, and they don’t usually reignite once they’re extinguished. With EVs, a battery fire may be inside a compartment that’s protected by shields, where the water isn’t directly impacting the flames. According to Klock, the point of fighting a battery fire is to lower the temperature to a point where the chemicals stop burning.

Fire departments have been encouraged to use thermal imaging to monitor the batteries even after the fire is out, according to a study prepared by the industry research firm Exponent, Inc. for the Fire Protection Research Foundation.

"We're gearing up to train more departments as we see more electric vehicles on the road," Klock said. "The real issue is education."

Departments are warned not to store a vehicle with a damaged battery within 50 feet of a building or another vehicle until the battery can be fully discharged. And the National Highway Traffic Safety Administration (NHTSA) has advised fire departments to allow lithium-ion battery fires to burn themselves out if there's no immediate threat to life or other property.

Tesla offers many of those same warnings to first responders in its Emergency Response Guide, in which the automaker advises that battery fires can take up to 24 hours to extinguish. The guide notes that “smoke or steam indicates that the battery is still heating,” and it urges that firefighters not release a vehicle to law enforcement officers or towing personnel until there has been no heating detected for one hour. A Tesla spokeswoman said the automaker had no comment on the NTSB report.

This investigation is just one of several automotive battery fires the NTSB has examined. In November 2011, the agency teamed up with NHTSA to look into a fire involving the lithium-ion battery in a Chevrolet Volt, where fire erupted on a vehicle three weeks after it underwent crash tests. From that investigation, NHTSA concluded that crash tests could compromise battery packs and lead to a fire, and also that turning the EV upside down in rollover tests also could short out the batteries and cause a fire.

The NTSB is also currently investigating a fire involving a Hollywood director’s Tesla Model S in Los Angeles on June 15. That incident drew a lot of Internet attention after the director’s wife, West Wing actress Mary McCormack, posted an eyewitness video on Twitter, showing bright orange flames shooting from under the front of the car, burning its tires and spreading quickly.

Lithium-ion battery fires aren’t new or unique to EVs. The NTSB and the Federal Aviation Administration have sounded alarms on lithium-ion battery fires in commercial aviation after some scary in-flight fires that were difficult to put out. Fires with Samsung’s Galaxy Note7 phone led to a high-profile recall. So-called hoverboards drew warnings from the Consumer Product Safety Commission in 2015 and again in 2017, after the agency logged more than 250 fire or overheating incidents.

While EVs may pose challenges for first responders during fires, experts say there’s no reason for consumers to be any more concerned for their safety in an electric car than a gasoline-powered vehicle. There are lots of ways conventional cars can catch fire, said Steven Risser, a researcher at Battelle Institute in Columbus, Ohio, who has studied electric-vehicle safety in a report funded by NHTSA. There are hundreds of conventional car fires a day, compared to one every once in a while with an EV, he said.

The challenge of lithium-ion batteries in cars is there hasn’t been nearly as much time to study the unique properties of battery packs, Risser said. And when things go bad, there’s a chance for them to go bad in a dramatic fashion, he said.

Consumers shouldn’t panic or shy away from buying EVs due to the fire risk, which is still relatively low, Risser said. They’re better off concentrating on aspects of the car that are likely to yield more safety, like better crash-test ratings, he said.

“We’re always consumed by the spectacular event,” Risser said. “If you’re playing the odds, you’re much more likely to be involved in a crash than a fire.”

COMMENTS





Name

Accessories,1,Auto Insurance,1,Auto Show,13,Autos,410,Autos News,5,Barn Finds,1,Buying,1,Car Shows,1,Car Tech,1,Certified Pre-Owned Vehicles,1,Chicago Auto Show,1,Classic Cars,11,Consumer Electronics Show,1,Customs & Classics,1,Detroit Auto Show,1,Driving,1,Enthusiasts,27,Frankfurt Motor Show,1,Fuel Economy,1,Gearheads,1,Geneva Motor Show,1,Hot Rod Power Tour,1,Imports,1,Just For Fun,2,Los Angeles Auto Show,1,Maintenance,1,Motorcycles,17,Motorsports,1,Muscle Cars,1,Muscle Cars & Hot Rods,1,New Bikes,1,New Car Deals,1,New York Auto Show,1,News,47,Ownership,10,Paris Motor Show,1,Pebble Beach Concours d'Elegance,1,Recalls,1,Research,9,Reviews,1,SEMA Show,1,Shanghai Auto Show,1,Sports and Exotics,1,Sports Cars,1,Supercars,1,Tech,1,Tokyo Motor Show,1,Trucks,1,
ltr
item
Autos - U.S. Daily News: How Tesla and Other EV Battery Fires Challenge First-Responder Tactics
How Tesla and Other EV Battery Fires Challenge First-Responder Tactics
https://2.bp.blogspot.com/-3Tg1WDOQj1A/WzZiXpeyKII/AAAAAAAAS2w/oUrtTB8YuL4mVlkCJRFHIGGQx0FRZre1ACLcBGAs/s1600/1.jpg
https://2.bp.blogspot.com/-3Tg1WDOQj1A/WzZiXpeyKII/AAAAAAAAS2w/oUrtTB8YuL4mVlkCJRFHIGGQx0FRZre1ACLcBGAs/s72-c/1.jpg
Autos - U.S. Daily News
https://autos.dailynews.us.com/2018/06/how-tesla-and-other-ev-battery-fires.html
https://autos.dailynews.us.com/
https://autos.dailynews.us.com/
https://autos.dailynews.us.com/2018/06/how-tesla-and-other-ev-battery-fires.html
true
7329154058020919259
UTF-8
Loaded All Posts Not found any posts VIEW ALL Read More Reply Cancel reply Delete By Home PAGES POSTS View All RECOMMENDED FOR YOU LABEL ARCHIVE SEARCH ALL POSTS Not found any post match with your request Back Home Sunday Monday Tuesday Wednesday Thursday Friday Saturday Sun Mon Tue Wed Thu Fri Sat January February March April May June July August September October November December Jan Feb Mar Apr May Jun Jul Aug Sep Oct Nov Dec just now 1 minute ago $$1$$ minutes ago 1 hour ago $$1$$ hours ago Yesterday $$1$$ days ago $$1$$ weeks ago more than 5 weeks ago Followers Follow THIS PREMIUM CONTENT IS LOCKED STEP 1: Share. STEP 2: Click the link you shared to unlock Copy All Code Select All Code All codes were copied to your clipboard Can not copy the codes / texts, please press [CTRL]+[C] (or CMD+C with Mac) to copy